This paper presents a method of measuring the temperature of water near a 1-mm-diameter magnetic sphere under induction heating. The method is based on the temperature dependence of the absorption coefficient of water at a wavelength of 1150 nm. In this study, two-dimensional images of the absorbance, which is the transverse projection of the absorption coefficient of water, were acquired by a near-infrared camera through a telecentric lens, and three-dimensional radial profiles of the temperature were then generated by applying inverse Abel transforms (IATs) to the absorbance profiles. To ensure the spherical symmetry of the temperature and the parallelity of the light rays, which are the conditions necessary to apply an IAT, the onset of free convection and the angles of deflection were evaluated. This paper also presents a method of estimating the heat generation rate in a sphere by fitting the numerical solutions of the thermal conduction equation to the measured temperatures. The temperatures and heat generation rates were observed to change consistently with the changes in the magnetic field intensity.
References
1.
E.
Rapoport
and Y.
Pleshivtseva
, Optimal Control of Induction Heating Processes
(CRC Press
, Boca Raton, FL
, 2006
).2.
T.
Bayerl
, M.
Duhovic
, P.
Mitschang
, and D.
Bhattacharyya
, “ The heating of polymer composites by electromagnetic induction—A review
,” Compos. A
57
, 27
–40
(2014
).3.
O.
Lucía
, P.
Maussion
, E. J.
Dede
, and J. M.
Burdío
, “ Induction heating technology and its applications: Past developments, current technology, and future challenges
,” IEEE Trans. Ind. Electron.
61
, 2509
–2520
(2014
).4.
5.
E. A.
Périgo
, G.
Hemery
, O.
Sandre
, D.
Ortega
, E.
Garaio
, F.
Plazaola
, and F. J.
Teran
, “ Fundamentals and advances in magnetic hyperthermia
,” Appl. Phys. Rev.
2
, 041302
(2015
).6.
A.
Kirschning
, L.
Kupracz
, and J.
Hartwig
, “ New synthetic opportunities in miniaturized flow reactors with inductive heating
,” Chem. Lett.
41
, 562
–570
(2012
).7.
H.-A.
Yang
, C.-W.
Lin
, C.-Y.
Peng
, and W.
Fang
, “ On the selective magnetic induction heating of micron scale structures
,” J. Micromech. Microeng.
16
, 1314
–1320
(2006
).8.
H.
Mamiya
and B.
Jeyadevan
, “ Hyperthermic effects of dissipative structures of magnetic nanoparticles in large alternating magnetic fields
,” Sci. Rep.
1
, 157
(2011
).9.
N.
Kakuta
, K.
Kondo
, A.
Ozaki
, H.
Arimoto
, and Y.
Yamada
, “ Temperature imaging of sub-millimeter-thick water using a near-infrared camera
,” Int. J. Heat Mass Transfer
52
, 4221
–4228
(2009
).10.
N.
Kakuta
, K.
Kondo
, H.
Arimoto
, and Y.
Yamada
, “ Reconstruction of cross-sectional temperature distributions of water around a thin heating wire by inverse Abel transform of near-infrared absorption images
,” Int. J. Heat Mass Transfer
77
, 852
–859
(2014
).11.
H. W.
Siesler
, Y.
Ozaki
, S.
Kawata
, and H. M.
Heise
, Near-Infrared Spectroscopy
(Wiley-VCH
, 2002
).12.
F. O.
Libnau
, O. M.
Kvalheim
, A. A.
Christy
, and J.
Toft
, “ Spectra of water in the near- and mid-infrared region
,” Vib. Spectrosc.
7
, 243
–254
(1994
).13.
N.
Kakuta
, Y.
Fukuhara
, K.
Kondo
, H.
Arimoto
, and Y.
Yamada
, “ Temperature imaging of water in a microchannel using thermal sensitivity of near-infrared absorption
,” Lab Chip
11
, 3479
–3486
(2011
).14.
M. J.
Buie
, J. T. P.
Pender
, J. P.
Holloway
, T.
Vincent
, P. L. G.
Ventzek
, and M. L.
Brake
, “ Abel's inversion applied to experimental spectroscopic data with off axis peaks
,” J. Quant. Spectrosc. Radiat. Trans.
55
, 231
–243
(1996
).15.
16.
L. M.
Yoder
, J. R.
Barker
, K. T.
Lorenz
, and D. W.
Chandler
, “ Ion imaging the recoil energy distribution following vibrational predissociation of triplet state pyrazine–Ar van der Waals clusters
,” Chem. Phys. Lett.
302
, 602
–608
(1999
).17.
F.
De Colle
, C.
de Burgo
, and A. C.
Raga
, “ Diagnostics of inhomogeneous stellar jets: Convolution effects and data reconstruction
,” Astron. Astrophys.
485
, 765
–772
(2008
).18.
K. M.
Green
, M. C.
Borrás
, P. P.
Woskov
, G. J.
Flores
III , K.
Hadidi
, and P.
Thomas
, “ Electronic excitation temperature profiles in an air microwave plasma torch
,” IEEE Trans. Plasma Sci.
29
, 399
–406
(2001
).19.
O.
Bendinelli
, “ Abel integral equation inversion and deconvolution by multi-Gaussian approximation
,” Astrophys. J.
366
, 599
–604
(1991
).20.
L.
Ciotti
, “ Inversion of the Abel equation for toroidal density distributions
,” Astro. phys. Lett. Commun.
40
, 85
–91
(2000
).21.
B.
Dörband
, H.
Müller
, and H.
Gross
, “ Metrology of optical components and systems
,” in Handbook of Optical System
, edited by H.
Gross
(Wiley-VCH
, 2012
), Vol. 5
.22.
H.
Jia
and G.
Gogos
, “ Laminar natural convection heat transfer from isothermal spheres
,” Int. J. Heat Mass Trans.
39
, 1603
–1615
(1996
).23.
V. N.
Kurdyumov
and A.
Liñán
, “ Free convection from a point source of heat, and heat transfer from spheres at small Grashof numbers
,” Int. J. Heat Mass Transfer
42
, 3849
–3860
(1999
).24.
C. M.
Vest
and M. L.
Lawson
, “ Onset of convection near a suddenly heated horizontal wire
,” Int. J. Heat Mass Transfer
15
, 1281
–1283
(1972
).25.
O. F.
Genceli
, “ The onset of manifest convection from suddenly heated horizontal cylinders
,” Wärme Stoffübertragung
13
, 163
–169
(1980
).26.
R.
Parsons
, Jr. and J. C.
Mulligan
, “ Transient free convection from a suddenly heated horizontal wire
,” Trans. ASME J. Heat Transfer
100
, 423
–428
(1978
).27.
D.
Ambrosini
, D.
Paoletti
, and G.
Schirripa Spagnolo
, “ Study of free-convective onset on a horizontal wire using speckle pattern interferometry
,” Int. J. Heat Mass Transfer
46
, 4145
–4155
(2003
).28.
29.
G. T.
Raithby
and K. G. T.
Hollands
, “ Natural convection
,” in Handbook of Heat Transfer
, edited by W. M.
Rohsenow
, J. P.
Hartnett
, and Y. I.
Cho
(McGraw-Hill
, 1998
), Chap. 4.30.
A. L.
Harvey
, J. S.
Gallagher
, and J. M. H. L.
Sengers
, “ Revised formulation for the refractive index of water and steam as a function of wavelength, temperature and density
,” J. Phys. Chem. Ref. Data
27
, 761
–774
(1998
).31.
M.
Daimon
and A.
Masumura
, “ Measurement of the refractive index of distilled water from the near-infrared region to the ultraviolet region
,” Appl. Opt.
48
, 3811
–3820
(2007
).32.
G.
Lohöfer
, “ Theory of an electromagnetically levitated metal sphere I: Absorbed power
,” SIAM J. Appl. Math.
49
, 567
–581
(1989
).33.
Y.
Bayazitoglu
and U. B.
Sathuvalli
, “ Eddy current heating in an electrically conducting sphere
,” J. Mater. Process. Manuf. Sci.
3
, 117
–141
(1994
).34.
H. W.
Jackson
, J. L.
Watkins
, S.
Chung
, and P.
Wagner
, “ Conductive sphere in a radio frequency field: Theory and applications to positioners, heating, and noncontact measurements
,” J. Appl. Phys.
79
, 3370
–3384
(1996
).35.
D. C.
Jiles
, J. B.
Thoelke
, and M. K.
Devine
, “ Numerical determination of hysteresis parameters for the modeling of magnetic properties using the theory of ferromagnetic hysteresis
,” IEEE Trans. Magn.
28
, 27
–35
(1992
).© 2017 Author(s).
2017
Author(s)
You do not currently have access to this content.
