Nano-materials exhibit superior performance over bulk materials in a variety of applications such as direct heat to electricity thermoelectric generators (TEGs) and many more. However, a gap still exists for the integration of these nano-materials into practical applications. This study explores the feasibility of utilizing the advantages of nano-materials' thermo-electric properties, using regular bulk technology. Present-day TEGs are often applied by dedicated thermoelectric materials such as semiconductor alloys (e.g., PbTe, BiTe) whereas the standard semiconductor materials such as the doped silicon have not been widely addressed, with limited exceptions of nanowires. This study attempts to close the gap between the nano-materials' properties and the well-established bulk devices, approached for the first time by exploiting the nano-metric dimensions of the conductive channel in metal-oxide-semiconductor (MOS) structures. A significantly higher electrical current than expected from a bulk silicon device has been experimentally measured as a result of the application of a positive gate voltage and a temperature gradient between the “source” and the “drain” terminals of a commercial NMOS transistor. This finding implies on a “quasi-nanowire” behaviour of the transistor channel, which can be easily controlled by the transistor's gate voltage that is applied. This phenomenon enables a considerable improvement of silicon based TEGs, fabricated by traditional silicon technology. Four times higher ZT values (TEG quality factor) compared to conventional bulk silicon have been observed for an off-the-shelf silicon device. By optimizing the device, it is believed that even higher ZT values can be achieved.

1.
G. J.
Snyder
and
E. S.
Toberer
, “
Complex thermoelectric materials
,”
Nat. Mater.
7
,
105
(
2008
).
2.
Y.
Gelbstein
,
Z.
Dashevsky
, and
M. P.
Dariel
, “
In-doped Pb0.5Sn0.5Te p-type samples prepared by powder metallurgical processing for thermoelectric applications
,”
Physica B
396
,
16
(
2007
).
3.
Y.
Gelbstein
and
J.
Davidow
, “
Highly efficient functional GexPb1xTe based thermoelectric alloys
,”
Phys. Chem. Chem. Phys.
16
(
37
),
20120
(
2014
).
4.
Y.
Gelbstein
, “
Phase morphology effects on the thermoelectric properties of Pb0.25Sn0.25Ge0.5Te
,”
Acta Mater.
61
(
5
),
1499
(
2013
).
5.
B.
Dado
,
Y.
Gelbstein
,
D.
Mogiliansky
,
V.
Ezersky
, and
M. P.
Dariel
, “
Structural evolution following spinodal decomposition of the pseudoternary compound (Pb0.3Sn0.1Ge0.6)Te
,”
J. Electron. Mater.
39
(
9
),
2165
(
2010
).
6.
O.
Ben-Yehuda
,
Y.
Gelbstein
,
Z.
Dashevsky
,
R.
Shuker
, and
M. P.
Dariel
,
J. Appl. Phys.
101
,
113707
(
2007
).
7.
G.
Rogl
,
A.
Grytsiv
,
M.
Falmbig
,
E.
Bauer
,
P.
Rogl
,
M.
Zehetbauer
, and
Y.
Gelbstein
, “
Thermoelectric properties of p-type didymium (DD) based skutterudites DDy(Fe1xNix)4Sb12 (0.13 ≤ x ≤ 0.25, 0.46 ≤ y ≤ 0.68)
,”
J. Alloys Compd.
537
,
242
(
2012
).
8.
A. I.
Hochbaum
,
R.
Chen
,
R. D.
Delgado
,
W.
Liang
,
E. C.
Garnett
,
M.
Najarian
,
A.
Majumdar
, and
P.
Yang
, “
Enhanced thermoelectric performance of rough silicon nanowires
,”
Nature
451
,
163
(
2008
).
9.
L.
Weber
and
E.
Gmelin
, “
Transport properties of silicon
,”
Appl. Phys. A
53
,
136
(
1991
).
10.
Z. H.
Abdul Rahman
,
M. H.
Md Khir
,
Z. A.
Burhanudin
,
K.
Ashraf
,
A. A. Abd.
Rahman
, and
S.
Sulaiman
, “
CMOS based thermal energy generator for low power devices
,”
Int. J. Appl. Sci. Eng. Res.
4
(
5
),
159
(
2013
); available at http://www.ijser.org/researchpaper/CMOS-BASED-THERMAL-ENERGY-GENERATOR-FOR-LOW-POWER-DEVICES.pdf.
11.
X.
Yu
,
Y.
Wang
,
Y.
Liu
,
T.
Li
,
H.
Zhou
,
X.
Gao
,
F.
Feng
,
T.
Roinila
, and
Y.
Wang
, “
CMOS MEMS-based thermoelectric generator with an efficient heat dissipation path
,”
J. Micromech. Microeng.
22
(
10
),
105011
(
2012
).
12.
D.
Dibra
,
M.
Stecher
,
A.
Lindemann
,
J.
Lutz
, and
C.
Kadow
, “
Seebeck difference-temperature sensors integrated into smart power technologies
,” in
Proceedings of the 21st International Symposium on Power Semiconductor Devices & ICs (ISPSD), Barcelona, Spain
,
2009
, p.
216
.
13.
S.
Kasap
,
Thermoelectric Effects in Metals: Thermocouples
(
University of Saskatchewan
,
Saskatoon, SK
, 1997); available at http://www.kasap.usask.ca/samples/Thermoelectric-Seebeck.pdf.
14.
S. M.
Sze
,
Physics of Semiconductor Devices
(
Wiley-Interscience
,
New York
,
1969
).
15.
A. W.
Van Herwaarden
, “
The Seebeck effect in silicon ICs
,”
Sens. Actuators
6
(
4
),
245
(
1984
).
16.
A. M.
Marconnet
,
M.
Asheghi
, and
K. E.
Goodson
, “
From the Casimir limit to phononic crystals: 20 years of phonon transport studies using silicon-on-insulator technology
,”
J. Heat Transfer
135
(
6
),
061601
(
2013
).
17.
M.
Kumar
,
A.
Bagga
, and
S.
Neeleshwar
, “
Tailoring of Seebeck coefficient with surface roughness effects in silicon sub-50-nm films
,”
Nanoscale Res. Lett.
7
,
169
(
2012
).
18.
J. A.
López-Villanueva
and
P.
Cartujo-Casinello
, “
Effects of the inversion layer centroid on MOSFET behaviour
,”
IEEE Trans. Electron Devices
44
(
11
),
1915
(
1997
).
You do not currently have access to this content.