Nyamplung (Calophyllum inophyllum) is a large evergreen plant, commonly called tamanu, beach Calophyllum, mastwood, or beautyleaf. Also known as a plant having many uses. However, the use of these plants is still limited because C. inophyllum oil contains dangerous poisons when consumed. So it is generally used and studied as raw material for biodiesel. Until now, the research conducted was limited to the beneficial substances in C. inophyllum seeds. In addition, C. inophyllum seeds oil contains a quite large Triacylglycerol (TAG), so it can be derived to be vegetable oil after removing the impurities. The objective of this study was to simulate the purification of TAG from C. inophyllum crude oil to become vegetable oil with Batchwise Solvent Extract (BSE) by using the Aspen HYSYS V10 application. Hereafter, the simulation finding the appropriate binary parameter coefficients and compares the results with experimental data from other literature in previous publications. The fluid packages (UNIQUAC and NRTL) and binary interaction parameters (LLE Unknown only, LLE All Binaries, and Immiscible) were well investigated. As a result, the most suitable type of fluid package and binary interaction parameter was LLE Unknown only and UNIQUAC, respectively, with an error of less than 1%. It was found that the TAG and free fatty acid purities of 98.53% (experimental data, 98.56%) and 0.81% (experimental data, 0.35%) were obtained after eight stages, respectively. Then the TAG recovery generated by the simulation was 71.13%, while the experimental data was 79.5%. Thus research proved that the model simulation can predict the operation conditions for producing vegetable oil from C. inophyllum crude oil.

1.
G.
Boskou
,
F. N.
Salta
,
A.
Chiou
,
E.
Troullidou
, and
N.
Andrikopoulos
, N. “
Conten of trans, trans-2,4 decadienal in deep-fried and pan-fried
”. (
Europian Journal Lipid Science Technology, South shileds
,
2006
)
2.
K.
Warner
, “Chemistry Of Frying Oils”, (
U.S Departemen of Agriculture
,
Lllinois
,
2002
).
3.
R.
Tambun
,. “Hibah Kompetisi Konten Mata Kuliah E-Learning USU INHERENT,” in
Buku Ajar Teknologi Oleokimia (TKK-322)
. (
Departemen Teknik Kimia Fakultas Teknik Universitas Sumatera Utara
,
Medan
2006
)
4.
BPS-Statistics Indonesia
. “
Indonesian Oil Palm Statistics 2018
” (
BPS Catalogue: 5504003
,
Jakarta
,
2019
). ISSN 1978-9947 No. 05130.1902
5.
S.
Rakhmawan
,
A.
Suryono
,
F.
Nofrida
, and Suheri. “
Indonesia Foreign Trade Statistics Expports 2020, Volume I
”. (
BPS-Statistics Indonesia catalog: 8202026
,
Jakarta
,
2021
) ISSN: 2745-3979
6.
R. P.
Mensink
, “
Health Effect of Saturated Fatty Acids
”. (
Maastricht University
,
The Netherlands
,
2013
)
7.
R. A. D.
Sartika
Pengaruh Asam Lemak Jenuh, Tidak Jenuh dan Asam Lemak Trans terhadap Kesehatan
”, (
KESMAS, Jurnal Kesehatan Masyarakat Nasional
,
Depok
,
2008
)
8.
D.
Noor
,
Geologi Lingkungan
. (
Graha Ilmu, Yogyakarta
,
2006
)
9.
Balitbanghut (Badan Penelitian dan Pengembangan Kehutanan)
. “
Nyamplung (Calophyllum inophyllum L) Sumber energi biofuel yang potensial
”.
Balitbang Forestry Indonesia
,
Jakarta
. (
2008
)
10.
H. A.
Hasibuan
,
L.
Afriana
, and dan
D.
Tamba
, “
The Effect of Bleaching Earth Dosage and Time for Bleaching Time of Crude Palm Oil Varied Deterioration of Bleachingability Index (DOBI) to The Quality od Product
”, (
Jurnal Teknologi Industri Pertanian
,
Medan
,
2016
)
11.
K.M.
Goh
 et al 
“Rapid assessment of total MCPD esters in palm-based cooking oil using ATR-FTIR application and chemometric analysis”. (Talanta, Selangor, 2019
).
Talanta
198
(
2019
)
215
223
. DOI:
12.
N. L.
Hanifah
,
N. D.
Yuliana
,
D.
Indrasti
,
Y.
Regiyana
,
C. A
Putri
, “Analisis 3-Monokloro-1,2-Propanadiol (3-MCPD) Ester dalam Minyak Sawit dengan Instrumen Kromatografi Gas-Spektroskopi Massa” (
Jurnal Ilmu Pertanian Indonesia (JIPI)
,
Bogor
,
2015
)
13.
IMCM.
Rietjens
, “
Refined hazard characterization of 3-MCPD using benchmark dose modelling
.”
European Journal of Lipid Science and Technology
,
114
(
10
):
1140
1147
(
2012
).
14.
C.G. Hamlet
CG
, “
Formation and occurrence of esters of 3-chloropropane-1,2-diol(3-CPD) in foods: What we know and what we assume
”,
European Journal of Lipid Science and Technology
,
113
(
3
):
279
303
(
2002
).
15.
H. W.
,
Aparamarta
,
T.
Saputra
,
A.
Claratika
,,
Y. H.
Ju
dan
S.
Gunawan
, “
Separation and Purification of Triacylglycerols from Nyamplung (Calophyllum inophyllum) Oil by Batchwise Solvent Extraction
”,
Industrial and Engineering Chemistry Research
,
55
.
3113
3119
(
2016
). DOI:
16.
BSN (Badan Standarisasi Nasional)
. “
SNI Minyak Goreng
” (SNI 3741:2013,
Jakarta
,
2013
).
17.
H.
Renon
, H. and
J. M
Prausnitz
, “
Local Compositions in Thermodynamic Excess Functions for Liquid Mixtures
”,
AIChE Journal, New York
,
14
,
135
144
(
1968
).
18.
D. S.
Abrams
and
J. M
Prausnitz
, “
Statistical Thermodynamics of Liquid Mixtures: A New Expression for the Excess Gibbs Energy of Partly or Completely Miscible Systems
”, (
AIChE Journal, NY
,
1975
),
21
,
116
128
.
19.
T.
Banerjee
,
M. K.
Singh
,
R. K.
Sahoo
, and
A.
Khanna
, “
Volume, Surface and UNIQUAC Interaction Parameters for Imidazolium Based Ionic Liquids and Polarizable Continuum Model
”,
Fluid Phase Equilibria
,
234
(
1-2
),
64
76
(
2005
), DOI:
20.
M.
Aznar
, (
2007
). “
Corelation of (liquid+liquid) Equilibrium of System Including Ionic Liquids
”, (
Brazilian Journal of Chemical Engineering, Brazil
,
2007
)
24
,
143
149
.
This content is only available via PDF.
You do not currently have access to this content.